So last week I finally got back into trying to fix it. All the air has to be out or the engine will over heat. I have verified temp with scan tool 180 deg. Geez it just gets worse with this car. I swapped them out last Thursday and so far so good. When it comes to your Saturn Vue, you want parts and products from only trusted brands.
If the thermostat is stuck closed, coolant cant flow which will result in engine overheating, if the thermostat is stuck in the open position, the engine will not reach operating temperatures in cold weather, passenger heater operations will also be weak. Thank You for visiting our site. Never mind my oil bill for this month and taxes were due the first. The engine coolant thermostat controls the flow of coolant through the radiator to enable the engine to reach and maintain its normal operating temperature. Once the tube is out simply unbolt the thermostat housing and install the new one. We determined this on the web sources and we think this is one of several awesome material for reference.
Some of our top Thermostat product brands are , and. We have been looking for this picture through on-line and it originated from professional resource. I'm hoping that the intake is O-ringed like most of the newer vehicles and don't need to replace the rings. I used a Tech 2 to monitor the fuel tank pressure sensor, and after smoke-testing the evap system and finding no leaks, I was back to my original temp issue. As far as replacing it, the thermostat is below the upper and lower intake manifold. Put a rag under it and cover the top so it does not spray.
I can send a photo if you have trouble locating. This refers to the temp the thermostat starts to open. Using your socket set, remove the bolts holding the thermostat housing in place. I have always had good luck using aftermarket tstats in Honda engines. Where the 2 bolts go in to hold the housing in place, the bosses were not as thick as the original. The water inlet housing connects the radiator hoses to the thermostat.
There was a Technical Service Bulletin from saturn about the problem, which means it happens alot but not quite enough to warrant a recall. The electronic heating of the thermostat is controlled by the engine control unit. The thermostat in a Saturn acts as a valve to control how much of the coolant reaches the engine, to keep it operating at an even temperature. I will probably compromise at 33 psi. Thanks, Jake The same code popped up on my 03 V6 Vue on Saturday night.
To relieve fuel pressure find if you have a schrade valve looks like a tire valve under a cap on the fuel rail. I am not saying that we see the same car s in year after year with this code and have to replace the t-stat each year. Posted on May 24, 2017 ok, your other question was too vague or you posted that question by accident without the specifics this fuse for your fuel pump for your 2005 Saturn Relay minivan is in your owners manual, i'll link a pdf version in case you don't have one in the glovebox page 5-12 shows you where the fusebox is under-the-hood. That means after the car begins to heat up the front one comes on and the rear is always on. When you… 2003 Saturn vue 4 cylinder O2 Sensors: The oxygen sensor that is refered to as bank 1 sensor 1 is located on the drivers side of the exhaust manifold, you can see it if you look directly down from above the rear of the motor. Got any more info on that electric heated coolant t-stat? So should it just be ignored in winter or is it actually doing damage? Cartridge filter, not a spin on.
Thanks, Jake No it doesnt. The cure is to replace the thermostat. What the heck does that mean? I am confident that the tolerance range of a 170 and 180 spec thermostat cross. One is in the front bank 1 before the catalytic converter, between the exhaust manifold and the catalytic converter, and the other is in the rear bank 2 after the catalytic converter and is screwed in. I am not responsible for any problems that you might incur by watching or following this video. I am actually more accustomed to this coolant flow setup because Honda has used this on every engine since 1984. ScanGauge says both the Jeep and Vue enter closed loop seconds after start-up and the Jeep runs like a top with a 180 and has for 19 mos now.
Am I hurting it by driving it right now? Refer to Engine Coolant Thermostat Housing Replacement. Nothing has changed as far as normal operating tempatures reading on the gage. We expect it deliver interesting things for saturn vue starter location niche. Advance Auto Parts has 14 different Thermostat for your vehicle, ready for shipping or in-store pick up. If within that time frame 102°C 216°F is reached then fan speed will change from high to low speed. That's the only way Advanced sells the 3.
The thermostat begins to open with 0V at 105°C 221°F and with 12V at 80°C 176°F. The codes were cleared and didn't come back for about 6 weeks. The parts person the Saturn dealer ask some of the mechanics what they do for this code. Do not forget to share and love our reference to help further develop our website. Like the man said above, for a P0128 chance the thermostat first! It is a grid controlled electronic wax pellet type. According to specs the cooling fans will increase to high speed when coolant temperature reaches 216°F. The instructions came from Alldata.